Murray 629104X5A Snow Blower Owners Owners Manual - English

Instruction Book Manuel d’instructions Snow Thrower chasse-neige Model 629104x5A modèle 629104x5A Read and keep this book for future reference. This book contains important information on SAFETY, ASSEMBLY, OPERATION, AND MAINTENANCE. Lisez et conservez ce manuel pour référence. Ce manuel contient des informations importantes concernant la SECURITE, LE MONTAGE, L’UTILISATION ET L’ENTRETIEN. F-031099L NOTE: This unit is equipped with an internal combustion engine and must not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).

Snow Blower and Snow Thrower User Manual Free Download. Snow Removal Operator’s Manual. Free Instruction Manual Download PDF.

If a spark arrester is used, it must be maintained in effective working order by the operator. In the State of California, the above is required by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. See an Authorized Service Center for a spark arrester for the muffler. Engine Exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. WASH HANDS AFTER HANDLING. REMARQUE : cette machine est équipée d’un moteur à combustion interne et ne doit pas être utilisée sur un terrain forestier, buissonnant ou herbeux non préparé, à moins que le dispositif d’échappement soit pourvu d’un pare-étincelles conforme à la législation locale ou de l’état (le cas échéant). Si un pare-étincelles est utilisé, celui-ci doit être maintenu en parfait état de fonctionnement par l’utilisateur. Au sein de l’état de Californie, la loi exige la prise en compte des précautions mentionnées ci-dessus (clause 4442 du California Public Resources Code). D’autres états peuvent présenter des lois similaires. Les lois fédérales s’appliquent sur les terres fédérales. S’adresser à un centre de maintenance agréé pour l’achat d’un pare-étincelles pour l’échappement. Les gaz d’échappement du moteur, certains éléments de leur composition, ainsi que certains organes du véhicule contiennent ou émettent des substances chimiques qui, selon l’État de Californie, peuvent causer le cancer, des malformations à la naissance, ou représentent un danger pour la reproduction. Les bornes et pôles de batterie et autres accessoires de ce type contiennent du plomb et des composés de plomb, substances chimiques qui, selon l’État de Californie, peuvent causer le cancer, des malformations à la naissance, ou représentent un danger pour la reproduction. F-031099L 2 1 5 9 8 10 11 6 20 2 17 1 2 3 4 18 2 14 13 16 7 1 15 17 7 19 12 3 2 5 3 17 1 4 20 1 3 2 5 1 2 6 7 6 5 F-031099L 3 7 5 2 8 7 3 15 4 1 9 4 2 3 1 10 4 1 3 5 6 2 1 11 12 2 F-031099L 4 ÁÁÁ ÁÁÁ ÁÁÁ Á Á 13 11 3 14 2 1 1 3 10 15 1 6 5 4 2 8 7 16 1 3 6 17 15 12 3 13 9 10 4 18 2 13 2 1 14 11 F-031099L 5 19 6 3 2 20 5 8 4 5 3 21 2 7 (4,8 mm) 6 (1,6 mm) 22 3 4 8 3 4 23 24 2 3 5 3 4 6 4 F-031099L 6 25 2- 9524 2- 3943 2 – 73826 F-031099L 7 ENGLISH CONTENTS PRODUCT INFORMATION OWNER’S INFORMATION INTERNATIONAL PICTORIALS ASSEMBLY OPERATION MAINTENANCE TROUBLE SHOOTING CHART 8 8 9 11 11 14 17 noted in this Limited Warranty, we shall, at our option, repair or replace at no cost to the original purchaser any part covered by this Limited Warranty during the applicable warranty period. Normal Wear Parts are defined as drive belts, augers, shear pins, tires and headlights. These parts are warranted to be free from defects in material and workmanship as delivered with the product. Any claim for repair or replacement of Normal Wear Parts must be made within thirty (30) days of the date of purchase. No claims involving damage caused from material use, abuse or misuse will be honored. This Murray, Inc. Two (2) Year Limited Warranty is your exclusive remedy; however, this warranty is void or does not apply to any unit that has been tampered with, altered, misused, abused or used for rental or other commercial and/or professional (non-homeowner) uses. Your warranty does not cover minor mechanical adjustments which are not due to any defect in material or workmanship. For assistance in making such adjustments, consult your Instruction Book. To make a claim under this Murray, Inc. Two (2) Year Limited Warranty, return the unit (or if authorized in advance, the defective part) along with your proof of purchase to an Authorized Service Center near you. To locate the nearest Authorized Service Center, call the Central Parts Distributor for your area shown in the list provided with your unit or check the Yellow Page listings in your local telephone directory. If you return the entire unit, we will repair the unit. If we authorize the return of the defective part only, we will either replace or repair the part.This Murray, Inc. Two (2) Year Limited Warranty gives you specific legal rights, and you may also have other rights which vary from state to state. This Limited Warranty is given in lieu of all other expressed and implied warranties including the implied warranty of merchantability and warranty of fitness for a particular purpose. If you need additional information on this written warranty or assistance in obtaining service, write: USA – MURRAY, INC. Outdoor Power Equipment Customer Service Department P.O. Box 268 Brentwood, Tennessee 37027 1-800-251-8007 CANADA – MURRAY CANADA, INC. Factory Customer Service 1195 Coutneypark Drive East Mississauga, Ont. L5T-1R1 1-800-661-6662 TWO YEAR LIMITED WARRANTY Murray, Inc. warrants to the original purchaser that this unit shall be free from defects in material and workmanship under normal use and service for a period of Two (2) Year from the date of purchase; however, this warranty does not cover engines, accessories (such as electric starters) and Normal Wear Parts (except as noted below) as the companies that manufacture these items furnish their own warranties and provide service through their authorized field service facilities. For additional information, see the warranties covering these particular parts. If you are uncertain whether your unit contains or is equipped with one or more of these parts, consult your dealer prior to purchase. Subject to the terms and conditions PRODUCT INFORMATION The owner must be certain that all the product information is included with the unit. This information includes the INSTRUCTION BOOKS, the REPLACEMENT PARTS and the WARRANTIES. This information must be included to make sure state laws and other laws are followed. reference. IMPORTANT: Many units are not assembled and are sold in cartons. It is the responsibility of the owner to make sure the assembly instructions in this manual are exactly followed. Other units are purchased in an assembled condition. On assembled units, it is the responsibility of the owner to make sure the unit is correctly assembled. The owner must carefully check the unit according to the instructions in this manual before it is first used. 2. 3. 4. 5. OWNER’S INFORMATION This instruction book is written for a person with some mechanical ability. Like most service books, not all the steps are described. Steps on how to loosen or tighten fasteners are steps anyone can follow with some mechanical ability. Read and follow these instructions before you use the unit. Know your product: If you understand the unit and how the unit operates, you will get the best performance. As you read this manual, compare the illustrations to the unit. Learn the location and the function of the controls. To help prevent an accident, follow the operating instructions and the safety rules. Keep this manual for future 6. 7. 8. Follow all the assembly and preparation instructions. Inspect the unit. Make sure that the operator of the unit knows how to correctly use all standard and accessory equipment. Operate the unit only with guards, shields, and other safety items in place and working correctly. Correctly adjust the unit. Service the unit only with authorized or approved replacement parts. Complete all maintenance on the unit. Environmental Awareness WARNING: Look for this symbol to indicate important safety precautions. This symbol indicates: “Attention! Become Alert! Your Safety Is At Risk. ” D D D D D D D D Do not fill the engine’s fuel tank completely full. Drain fuel for off-season storage. Use only unleaded gasoline. Service the air cleaner regularly. Change oil regularly. Use 5W-30 oil. Tune-up the engine regularly. Keep equipment in efficient operating condition. Dispose of used engine oil properly. Responsibility Of The Owner The responsibility of the owner is to follow the instructions below. 1. Carefully read and follow the rules for safe operation. F-031099L 8 ENGLISH INTERNATIONAL PICTORIALS IMPORTANT: The following pictorials are located on your unit or on literature supplied with the product. Before you operate the unit, learn and understand the purpose for each pictorial. Safety Warning Symbols 26 DANGER Thrown Objects. Keep Bystanders Away. DANGER Thrown Objects. Keep Bystanders Away. WARNING IMPORTANT Read Owner’s Manual Before Operating This Machine. DANGER Avoid Injury From Rotating Auger. Keep Hands, Feet And Clothing Away. WARNING Hot Surface STOP DANGER Stop The Engine Before Unclogging Discharge Chute! Control And Operating Symbols Slow Fast Electric Start Engine Start Engine Run Engine Off Engine Stop On Choke Off Choke On N Neutral Ignition Off Forward Reverse Throttle Primer Button Ignition Key Ignition On Push To Engage Electric Starter Engage Auger Clutch Auger Collector Discharge DOWN Discharge UP Discharge LEFT Discharge RIGHT Drive Clutch Fuel Oil Fuel Oil Mixture KGS KGS Weight Transfer Lift Handle To Engage F-031099L Weight Transfer Depress Pedal To Disengage Transmission Ignition Key Insert To Run, Pull Out To Stop. 9 ENGLISH Safe Operation Practices for Snow Throwers As Recommended By: American National Standards Institute. IMPORTANT: Safety standards require operator presence controls to minimize the risk of injury. Your snow thrower is equipped with such controls. Do not attempt to defeat the function of the operator presence control under any circumstances. 7. Never attempt to make any adjustments while the engine (motor) is running (except when specifically recommended by manufacturer). 8. Let engine (motor) and snow thrower adjust to outdoor temperatures before starting to clear snow. 9. Always wear safety glasses or eye shields during operation or while performing an adjustment or repair to protect eyes from foreign objects that may be thrown from the snow thrower. 11. Do not clear snow across the face of slopes. Exercise extreme caution when changing direction on slopes. Do not attempt to clear steep slopes. 12. Never operate the snow thrower without proper guards, plates or other safety protective devices in place. 13. Never operate the snow thrower near enclosures, automobiles, window wells, drop- offs, and the like without proper adjustment of the snow discharge angle. Keep children and pets away. 14. Do not overload the machine capacity by attempting to clear snow at too fast a rate. 15. Never operate the machine at high transport speeds on slippery surfaces. Look behind and use care when backing up. 16. Never direct discharge at bystanders or allow anyone in front of the unit. 17. Disengage power to the collector/impeller when snow thrower is transported or not in use. 18. Use only attachments and accessories approved by the manufacturer of the snow thrower (such as tire chains, electric start kits, ect.). 19. Never operate the snow thrower without good visibility or light. Always be sure of your footing and keep a firm hold on the handles. Walk;never run. 20. Do not over- reach. Keep proper footing and balance at all times. 21. Exercise caution if operating on steep sloping surfaces. 22. This snow thrower is for use on sidewalks, driveways and other ground level surfaces. 23. Do not use the snow thrower on surfaces above ground level such as roofs of residences, garages, porches or other such structures or buildings. Training 1. Read the operating and service instruction manual carefully. Be thoroughly familiar with the controls and the proper use of the equipment. Know how to stop the unit and disengage the controls quickly. 2. Never allow children to operate the equipment. Never allow adults to operate the equipment without proper instruction. 3. Keep the area of operation clear of all persons, particularly small children and pets. 4. Exercise caution to avoid slipping or falling especially when operating in reverse. Operation 1. Do not operate this machine if you are taking drugs or other medication which can cause drowsiness or affect your ability to operate this machine. 2. Do not use this machine if you are mentally or physically unable to operate this machine safely. 3. Do not put hands or feet near or under rotating parts. Keep clear of the discharge opening at all times. 4. Exercise extreme caution when operating on or crossing gravel drives, walks or roads. Stay alert for hidden hazards or traffic. 5. After striking a foreign object, stop the engine (motor), remove the wire from the spark plug, thoroughly inspect snow thrower for any damage, and repair the damage before restarting and operating the snow thrower. 6. If the unit should start to vibrate abnormally, stop the engine (motor) and check immediately for the cause. Vibration is generally a warning of trouble. 7. Stop the engine (motor) whenever you leave the operating position, before unclogging the auger/impeller housing or discharge chute and when making any repairs, adjustments, or inspections. 8. When cleaning, repairing, or inspecting, make certain the auger/impeller and all moving parts have stopped and all controls are disengaged. Disconnect the spark plug wire and keep the wire away from the spark plug to prevent accidental starting. 9. Take all possible precautions when leaving the snow thrower unattended. Disengage the auger/ impeller, stop engine (motor), and remove key. 10. Do not run the engine (motor) indoors, except when starting the engine (motor) and for transporting the snow thrower in or out of the building. Open the outside doors; exhaust fumes are dangerous (containing CARBON MONOXIDE, an ODORLESS and DEADLY GAS). Preparation 1. Thoroughly inspect the area where the equipment is to be used and remove all doormats, sleds, boards, wires, and other foreign objects. 2. Disengage all clutches before starting the engine (motor). 3. Do not operate the equipment without wearing adequate winter outer garments. Wear footwear that will improve footing on slippery surfaces. 4. Handle fuel with care; it is highly flammable. a. Use an approved fuel container. b. Never remove fuel tank cap or add fuel to a running engine (motor) or hot engine (motor). c. Fill fuel tank outdoors with extreme care. Never fill fuel tank indoors. Maintenance And Storage 1. Check shear bolts and other bolts at frequent intervals for proper tightness to be sure the equipment is in safe working condition. 2. Never store the snow thrower with fuel in the tank inside a building where ignition sources are present such as hot water and space heaters, clothes dryers, and the like. Allow the engine (motor) to cool before storing in any enclosure. 3. Always refer to operator’s guide instructions for important details if the snow thrower is to be stored for an extended period. 4. Maintain or replace safety and instruction labels, as necessary. 5. Run the snow thrower a few minutes after throwing snow to prevent freeze- up of the auger/impelle …..

Gooding, Jefferson, Jerome, Lemhi, Lincoln, Madison, Minidoka, Oneida, Power, Teton, Twin Falls) Montana (all counties except Flathead, Lake, Lincoln, Mineral, Missoulo, Ravalli, and Sanders), Utah, Wyoming GULF COAST ENGINE, INC. 4202 Russell Dr. Corpus Christi, TX. 78408 1-800-825-6999 FAX 1-888-888-7036 Arkansas (counties Hempstead, Howard, Lafayette, Little River, Miller, Nevada, Pike, Sevier) New Mexico, Oklahoma, Texas, Mexico BROWN & WISER, INC. 9991 S.W. Avery Street Tualatin, OR. 97062 (503) 692-0330 1-800-882-4782 FAX (503) 691-2041 Alaska, Idaho (counties Ada, Adams, Benewah, Boise, Bonner, Boundry, Canyon, Clearwater, Elmore, Gem, Idaho, Kooten, Latah, Lewis, Nez Perce, Owyee, Payette, Ravalli, Shoshone, Valley, Washington), Montana (counties Flathead, Lake, Lincoln, Mineral, Missoulo, Ravalli, Sanders), Oregon, Washington WISCONSIN MAGNETO, INC. 4727 N. Teutonia Ave. Milwaukee, WI. 53209 1-800-733-7388 FAX 1-800-733-0127 Illinois (N. of Hwy. 80), Michigan (upper Peninsula), Minnesota, North & South Dakota, Wisconsin GARDNER, INC. 3641 Interchange Road Columbus, OH. 43204-1499 1-800-848-8946 FAX 1-800-626-4735 Alabama, Arkansas (except these counties: Hempstead, Howard, Lafayette, Little River, Miller, Nevada, Pike, Sevier), Connecticut, Delaware, District of Columbia, Florida, Georgia, Illinois (South of Hwy. 80),, Indiana, Iowa, Kansas, Kentucky, Louisiana, Maine, Maryland, Massachusetts, Michigan (except upper Peninsula), Mississippi, Missouri, Nebraska, New Hampshire, New Jersey, New York, North Carolina, Ohio, Pennsylvania, Rhode Island, South Carolina, Tennessee, Vermont, Virgina, West Virginia Puerto Rico CPT CANADA POWER TECHNOLOGY LIMITED Mississauga 161 Watline Avenue Mississauga, Ontario L4Z-1P2 (905) 890-6900 1-800-861-9559 Edmonton 101-10411-178th Street Edmonton, Alberta T5S 1R5 (780) 453-5791 1-800-861-9559 Ville St-Laurent 234 Migneron Street Ville St-Laurent, Quebec H4T 1Y7 (514) 731-3559 1-800-861-9559 Canada F-031099L 52 …

Publisher: www.murray.com